2005 Dodge Durango Fuel System, Gasoline Problems
- 443
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 443 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 41 records
- fuel system · 32 records
- system gasoline · 27 records
- failure mileage · 25 records
- storage tank · 25 records
- tank assembly · 25 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 177 |
| 30–60k mi | 141 |
| 100–150k mi | 42 |
| 1–30k mi | 26 |
| 150–400k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, gasoline would spew back from the filler neck and the fuel pump would not shut off when the fuel tank was full. The contact referenced nhtsa campaign id number: 09v003000 (fuel system, gasoline: storage tank assembly but was advised by the manufacturer that the vehicle was not included in the recall. The vehicle was not…
ODI 10397043
Fuel System, Gasoline
When filling vehicle with fuel, gas spews out all over car ground and people, creating a fire hazard at a very bad time . *tr
ODI 10292077
Fuel System, Gasoline
I have 2005 dodge durango that spills gasoline all over the outside of the vehicle when filling it up and the gas pump turns off. This happens everytime the tank is filled completely up. Contacted dodge but they said my vehicle identification number isn't part of the recall # 09v003000. Others are having this same issue when i searched the web for information. Here is just one website that folks are reporting the…
ODI 10329308
Fuel System, Gasoline
My vehicle spits back fuel everytime i fill up. I believe it is being cause by stuck inlet check values in the fuel tank filler tubes. There is a recall on my model vehicle for this problem. The nhtsa action number for this recall is rq08005. But i am being told by the dealer than my vin number is not included in this recall, however i am having this problem. *tr
ODI 10298969
Fuel System, Gasoline
Every time durango is filled, gasoline pours out of the spout. *tr
ODI 10293712
Fuel System, Gasoline
The fuel tank filler tube inlet check valve does not fully close at the end of refueling. This allows some fuel to escape from the vehicle filler neck spraying on my wife every fill up. *tr
ODI 10301684
Fuel System, Gasoline · Tank Assembly
When completed pumping gas into the vehicle and removing the gas pump nozzle, the gas comes shooting back out of the tank. Suv was taken back to place of purchase and a new gas tank was installed in approx. Beginning of october 2009.. The problem is now occurring again in june each time gas is pumped into the vehicle.. Looked up online recalls on vehicle. There is a recall on vehicle for this year make and model for…
ODI 10335646
Fuel System, Gasoline
2005 dodge durango fuel overflow/splash. About a year ago i noticed the fuel pump would not shut off when refueling which cause a great amount of fuel to splash back at the person filling the tank. I took my vehicle in for maintenance and was told by dodge that it was not under recall and it would cost me $600 plus to fix. I went to a different dealer recently and was told the same. This is a severe safety issue!…
ODI 10358590
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. Contact stated that while refueling, fuel would escape from the filler neck. The dealer and the manufacturer were contacted who referenced nhtsa campaign id number: 05v034000 (fuel system, gasoline: storage: tank assembly: filler pipe and cap) but advised the contact that the vehicle was not included in the recall. The vehicle was repaired. The failure mileage was 55,000…
ODI 10428922
Fuel System, Gasoline
Fuel spits back from filler neck when filling the tank. The fuel spit back and spillage is occurring at the last portion of the fill about five seconds after the nozzle kicks off. *tr
ODI 10292254
Fuel System, Gasoline
Every time i fill up with gas, fuel comes gushing out of my fuel tank. At first, i thought it was the gas station nozzle, but realized that after using several different stations, this was not the case. After completing some research online, i saw there was a safety recall issued for this same complaint. I then contacted chrysler and was informed that the vin on my vehicle was not covered under the recall. I asked…
ODI 10375872
Fuel System, Gasoline
Fuel spills out of filler neck every time i try to fuel up no matter what station or how slowly i try to fill. I get gasoline all over my vehicle, myself, and the ground. Dodge dealer told me it needs a fuel tank replaced at $750. I find a recall on this exact problem for 2005 durangos, but they tell me it doesn't apply to mine. Same problem, same vehicle - are they yanking my chain? *tr
ODI 10286357
Engine And Engine Cooling · Fuel System, Gasoline
Ticking sound and a exhaust smell in vehicle caused me to take my car to a local repair shop to have exhaust manifold gasket replaced. The technician found that a bolt had broken off a was sitting in the heat shield. *tr
ODI 10427078
Fuel System, Gasoline
When filling the gas tank, the gas will spill out of the hole when it is about full. This will occur every time you try to fill up the tank unless you stand beside the tank and listen to when you think it is about full. Since this has happened, we have had the gas tank replaced. Daimlerchrysler put a recall on 26,000 vehicles for this same type of complaint. It is complaint # e01, but when i called them, they are…
ODI 10284717
Fuel System, Gasoline
When my durango is filled with gas it will not automatically shut off the gas pump but instead gas comes spitting out the fuel opening. This occurs every time that i fill my vehicle up. I do not fill it up anymore because i don't want gas all over my clothes, shoes or down the side of my vehicle and not to mention the puddle of gas that accumulates on the ground. I notified my local dodge dealer as well as…
ODI 10454941
Fuel System, Gasoline
When filling gas tank, fuel pump shuts off when full, then gas is expelled from the tank. My car was manufactured in dec 04 and the recall covered cars manufactured through nov 04. Is there any recourse or appeal available to get this recall extended. Clearly dodge didn't solve the problem as soon as they think they did, judging by the hundreds of us with the same problem. *tr
ODI 10327030
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, gasoline would spew back out from the filler tube and would occur frequently. The dealer advised that there were no related recalls on the vehicle. The vehicle was neither inspected nor repaired. The failure mileage was approximately 55,000 and the current mileage was approximately 65,000.
ODI 10352928
Fuel System, Gasoline
I just bought a used 2005 dodge durango last week. Each time i've tried to put gas into it, it spits it right back up. In order to put $20 worth of gas in, i have to pump and let go about 20 times (about every dollar inteval) and even then, some gas squirts out or atleast gurgles around the opening when i pull the nozzle out. I read about the recall online and had a new gas tank put in today, free of charge of…
ODI 10280056
Fuel System, Gasoline
Upon completion of fueling, when removing hose, gas splashes out with force,enough to soak a body from neck to ankles with gas. *tr
ODI 10352929
Fuel System, Gasoline · Tank Assembly
I have a 2005 dodge durango that was manufactured 03/2005. I have a fuel tank that is malfunctioning just like what was referenced in your case #: 09v003000. I have been in contact with the local dealership and the national dodge website and they tell me that the recall does not effect my vehicle. However, the recall is for the exact same thing. They are wanting 400 to replace this tank. I feel that it is a huge…
ODI 10278137
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, fuel began to spill onto the ground and the vehicle. The vehicle was taken to the dealer who advised that the fuel tank would need replacing and that the vehicle was not included in the recall associated with the failure under nhtsa campaign id number: 09v003000, ( fuel system, gasoline: storage: tank assembly). The…
ODI 10414644
Fuel System, Gasoline
Fuel sprays out of filler neck when gas tank is full when fueling. Approximately 1/4 gallon. *tr
ODI 10285196
Fuel System, Gasoline
I bought this vehicle used back in 2009. I am in the auto industry and bought from a reputable dealer and checked history for any crashes. Also no signs of any body repair or anything being not original in the fuel system. I like many others cannot fill up my fuel tank without getting sprayed with gasoline! Anytime the gas station pump is allowed to shut itself off it sprays at least a half gallon of fuel out. This…
ODI 10445480
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that gasoline fuel would spew back out onto the ground when refueling the vehicle. Neither the dealer nor the manufacturer offered any assistance when contacted since the vehicle was not included in nhtsa campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). No repairs were performed. The current mileage was…
ODI 10448999
Fuel System, Gasoline
2005 dodge durango for the past two years everytime i fill it up with gas, about a gallon or so shoots back out of the tank because their is a faulty part. I have called dodge several times and they keep telling that my vehicle isn't in the recall; but if the part had been made in a different factory that had the defect issues then it would be eligible for a recall. I am sick and tired of wasting my money on the gas…
ODI 10411619