2004 Dodge Durango Fuel/Propulsion System Problems
- 16
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 16 stored complaint records:
- 1 indicate a crash
- 1 indicate injury
- 0 indicate fire
What owners report
- fuel pump · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 4 |
| 60–100k mi | 3 |
| 150–400k mi | 3 |
| 30–60k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine · Fuel/Propulsion System · Vehicle Speed Control
My vehicle stalls in the rain. It stalls at a stop or rolling speeds. It idles rough first and then stalls or shuts off. Sometimes the check engine light will come on, but not always. This only occurs in the rain. I've had several mechanics look at it, and they can't figure out how to solve the problem. I've spent a lot of money trying to get this fixed. Through online research, i've discovered that many other…
ODI 11129432
Air Bags · Fuel/Propulsion System · Power Train
The transfer case will make noise when unlocking the doors, it will also engage and change the awd by itself to 4lock when driving on the road. It can cause seriouse hard or accident. The airbags on both driver and passenger side light will engage and can cause seriouse harm. The fuel pump seems like it has an air bubble inside and shoots out gasoline and also can cause seriouse harm. All of these problems occurs…
ODI 11088986
Fuel/Propulsion System
I have read dodge is aware of this issue, and no one has done anything to protect the consumer. The gas tank does not fill and spits fuel out when about 2/3 full. Also the tank is collapsing do to the pressure that builds up. This is a big safety concern that needs some kind of action taken. People need to stop turning their heads away from these problems. I have taken this to a mechanic who has stated this is a…
ODI 11065463
Fuel/Propulsion System
I can not fill the gas tank,fuel starts to come out of neck about2/3 full this has been an on going problem
ODI 11056182
Body · Engine · Fuel/Propulsion System
Gas and body issues: when you go to fill up the gas sprays out. I have a vert strong smell of gas and the lower finder by the wheel well has rusted badly. Motor: whenever there is heavy rain, my car will stop running. Most recently when i turn on the ac or heater the car stalls. I also just recently had to change out a manifold which caused another set of problems. I owned a durango before this one and loved it.…
ODI 10909547
Fuel/Propulsion System
Takata recall - my truck smells like gas on the inside & outside & is leaking gas the fuel tank has collapsed for the second time i have replaced it 5years ago & now is collapsed again is there any recall do to it being a reoccurring issue , afraid that is going to catch on fire while driving it or parked any little spark probably can ignite it into flames.
ODI 10850539
Engine · Fuel/Propulsion System
Purchased vehicle in april 2013. First week fuel pump went out. In late 2013 replaced fuel pump again after it went out a second time. By now we realized that if we drove the vehicle in the rain or through a car wash it would shutter and cut off. In early 2014 the fuel pump went out again. We replaced fuel pump again and also cowl as we had found information that the cowl was allowing water to drip down on the…
ODI 10794839
Fuel/Propulsion System
Every time i fuel my durango it spews gasoline after the pump is shut off.
ODI 10839782
Engine · Fuel/Propulsion System · Unknown Or Other
I have had this suv for just a few months the day i mad my first payment it went into the shop to be fixed. At first it was apparently my #5 piston shot thru the block with only 120,000 mile on it. Than after spending the $3,700 to get that fixed it was still smoking and having issues. Next thing i know it is now the intake manifold whitch was another $700.00 and it was 84 in back order when i seen that i pulled it…
ODI 10781673
Fuel/Propulsion System
I was filling up my gas tank when the car started spitting out gas at me. Luckily i stopped it fast enough but had some gas on me and all over the side of my car. I've looked this up and it seems to be a big problem with the durangos. I really would like to fill my car up without worrying about being covered in gas or my car starting to rust. *dt
ODI 10667452
Body · Fuel/Propulsion System
Left rear quarter panel shows rust to the side of the fuel door lid. Rust is through panel. Paint and body bubbling up, condition is crossing over to the left rear wheel area.
ODI 10972035
Fuel/Propulsion System
Fuel tank has a problem on top it rust out & the vehicle will not pass a emission test. To pass you have replace the tank &the fuel pump.a cost of $2200 . I called chrysler they said to bad. They said there are no problems. I saw (4 durangos) that have this problem. My whole thing is they will replace a engine on a police vehicle with 150000 mi on them but forget the gas tank. That is a real problem. *tr
ODI 10483192
Electrical System · Engine · Fuel/Propulsion System
My 2004 dodge durango limited stalls at slow speeds and when coming to a stop and also while making turns. Have had at dealership and they cannot find out what is causing this since there are no engine codes. Vehicle is becoming very dangerous to drive due to this issue. Durango has a 5.7 hemi engine. Why is there no recalls on this issue when it involves over four years of production? Are we waiting on a incident…
ODI 10542367
Body · Fuel/Propulsion System
The wheel well and body surrounding wheel well has rusted through, the driver's door has rusted on door. The lift gate has rusted in multiple spots mostly on the bottom edge. The fuel tank overflows when pumping. *js
ODI 10598324
Fuel/Propulsion System
Gas leaks when filling tank gas fumes in car taken to the dealer several times. *tr
ODI 10504515
Air Bags · Fuel/Propulsion System · Service Brakes
I was driving my wife to work that morning, it was a bright clear day. I was parked half out of garage. As my wife came out of the laundry room i touched the gas to pull forward. However this did not happen, suv revved all the way up and would not rev down. I tried to apply brakes but they did not work. I came within a foot of killing my wife. To make this so bad i complained about this before so has my wife. My suv…
Crash reported · 1 injury
ODI 10764440