2005 Dodge Durango Fuel System, Gasoline Problems
- 443
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 443 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 41 records
- fuel system · 32 records
- system gasoline · 27 records
- failure mileage · 25 records
- storage tank · 25 records
- tank assembly · 25 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 177 |
| 30–60k mi | 141 |
| 100–150k mi | 42 |
| 1–30k mi | 26 |
| 150–400k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline · Tank Assembly
2005 dodge durango: when fueling the vehicle to full the vehicle spits gas back at you and this isn't a small amount either. This occurs mostly when fueling the vehicle to full. This has happened since we purchased the vehicle in december 2008. There is a recall number: 09v003000 and 05v034000; chrysler claims my vehicle had the recalled performed, but i think they never fixed the problem. *tr
ODI 10291246
Fuel System, Gasoline
Tl*the contact owns 2005 dodge durango. The contact stated that when fuel was added to the vehicle the fuel tank would not shut off when the vehicle was full. The failure caused gasoline to spill out of the fuel tank. The vehicle was not repaired. The manufacturer was contacted and stated that they are aware of the failure and that there was a recall for the failure but his vehicle was not included. The failure…
ODI 10373543
Fuel System, Gasoline
Gas gushes out of the fill nozzle of my 2005 dodge durango ltd spraying the vehicle, ground, gas pump and myself with gasoline. I bought this vehicle used , jan. 3, 2009, and this has occurred everytime that i fill up with gas, no matter how slowly the delivery rate of the pump. I contacted dodge customer service and was told that since the recall was performed in december of 2004 and my vehicle is not covered by…
ODI 10262492
Fuel System, Gasoline
Gas over flows all over me and ground when filling. *tr
ODI 10263216
Fuel System, Gasoline
When putting gasoline into my tank, gas will shoot out of the tank periodically throughout the process.. I estimate that approximately 4-5 cups of gas end up on the ground, on my feet, and on my clothes. It will continually spew out unless i barely depress the fill up arm at the pump. This results in not only gasoline over the ground and myself, but it will often take me about 30 minutes to fill my tank. I contacted…
ODI 10373840
Fuel System, Gasoline
I own a 2005 dodge durango with 5.7 lt. Hemi.. Every time i put fuel in the vehicle gas sprays out onto the ground. I did some research on the problem and found that there was a recall for this problem.. I took the vehicle to a dodge dealer to have this issue addressed. The dealership ran the vin and advised me that. The gas spillage issue can be resolved but it will not be covered by dodge because the vin does not…
ODI 10325669
Fuel System, Gasoline
Fuel tank spillage in dodge durango 2005. When filling up the tank gas spews out after gas is turned off. My vehicle is not included in the prior recall but has the exact same problem. Reported this problem a year ago and have not heard anything. *tr
ODI 10317997
Fuel System, Gasoline
When i fill of the gas tank it overflows after shut off. Has happened about 7 times. On january 26, 2009 dodge filed a notice of defect on this problem but the company and the dealers say my car is not included in the recall. *tr
ODI 10259072
Fuel System, Gasoline
GAS OVERFLOW WHEN TANK IS FILLED. *TR
ODI 10257210
Fuel System, Gasoline
While filling up the fuel tank (every time), fuel pours (shoots) out through the filler neck once the tank is filled. Fuel either rushes out and down the outside of the vehicle or it squirts out dangerously with a significant amount of force. Researching this problem, i have found an official recall from dodge for 2005 durangos, but calls to dodge and inquiries on their website indicate that my particular vehicle is…
ODI 10252256
Fuel System, Gasoline
Fuel spit back when filling gas tank. Just started within the week. It happened the last two times i filled my tank. I assume it has a bad roll over valve or fill limit vent valve. I called the dealer and he thought it was the roll over valve and would be approx. $250 to fix. 2005 dodge durango w/hemi - 48,539 miles. *tr
ODI 10252116
Fuel System, Gasoline
2005 dodge durango gasoline spurts (several ounces) from the tank filling port when fuel tank is full and the nozzle clicks off. This defect began to appear at approx 65,000 miles. Although there are existing recalls for the same defect on other 2005 dodge durangos, this vehicle is not covered. *tr
ODI 10276311
Filler Pipe And Cap · Fuel System, Gasoline
Tl*the contact owns a 2005 dodge durango. Whenever the contact fills the fuel tank, gasoline sprays out of the tank. The fuel nozzle stops when the tank is full, but fuel still sprays out of the tank. The vehicle was taken to the authorized dealer for inspection. The technician discovered nhtsa campaign id number 05v034000 (fuel system, gasoline:storage;tank assembly;filler pipe and cap); however, the vin was not…
ODI 10251791
Fuel System, Gasoline
When filling up at any gas station, the pump will not automatically shut off and gasoline shoots out of the filler neck. A significant amount shoots out under pressure. This occurs every time that i fill up for approximately the last ten fill ups. There are two recall campaigns regarding this exact issue, yet chrysler denies my claim on the basis that my vin is not included in either campaign. I spoke to the nhtsa…
ODI 10260416
Filler Pipe And Cap · Fuel System, Gasoline
The filler tube inlet check valve not fully close and allows fuel to escape from the vehicle filler neck. There is a recall on this but when i call they said my vin number was not covered for this recall. Nhtsa campaign number: 05v034000. This has been happening since the beginning of december everytime i fill my tank. *tr
ODI 10254873
Fuel System, Gasoline · Tank Assembly
My 2005 dodge durango has a problem described in the following recalls by the nhtsa: 05v034000 and 09v003000. I contacted the dodge dealership where i bought my vehicle and they told me there was not a recall on my vin, to contact dodge corporation. Dodge corporation verified that my durango was not part of the recall, yet it has the 'spit back' problem described in the recall. *tr
ODI 10277572
Fuel System, Gasoline
There was no lead up, the gas tank just started overflowing and it would not shut off the automatic shut off on the gas pump when fueling the tank. It happens everytime that we fill up using the automatic shut off feature on a gas pump. The result is several ounces (just a guess, but it is a lot) of gasoline running down the side of the truck, onto the ground and even splashing onto an unsuspecting truck owner. We…
ODI 10257262
Fuel System, Gasoline
While filling up the fuel tank (every time), fuel pours out through the filler neck once the tank is filled. Depending upon the type of fuel pump being used, fuel either rushes out and down the outside of the vehicle or it squirts out dangerously with a significant amount of force. Researching this problem, i have found an official recall from dodge for 2005 durangos, but calls to dodge and inquiries on their…
ODI 10249692
Fuel System, Gasoline
Dodge durango 2005, recently has begun to blow gas out of the tank after filling. Every time i fill the tank a large amount of gasoline explodes from the tank and constitutes a nuisance and a serious hazard due to the gas spill. *tr
ODI 10256177
Fuel System, Gasoline
My 2002 dodge durango shuts off while driving, this happens everytime i drive this vehicle, therefore will not take it on any highways or were there is alot of traffic, once it shuts off i have no steering or brakes and have been very close to being in accidents. This is going to kill someone and i hope and pray to god this is not what it is going to take for dodge to do a recall. It is just totally unbelievable…
ODI 10435424
Fuel System, Gasoline
Tl*the contact owns a 2005 dodge durango. When the gas tank was filled, the contact noticed that fuel would spill back out. The vehicle was taken to the dealer and they replaced a few parts; however, the contact does not remember which ones specifically. The failure was not corrected and the repair caused the vehicle to stall. The vehicle was taken back to the dealer. The dealer stated that the fuel tank needed to…
ODI 10259469
Fuel System, Gasoline
From time vehicle purchased it would overflow gas when trying to fill tank,recently ( approx. 93000 miles)a strong odor of gas is smelt when standing by drivers side door and also on floor in passenger area.it also appears that there may be a fuel leak coming from the top of the tank. Talked with dodge and they are saying this is not a recall issue and i will have to pay for repairs. Research i have done on the…
ODI 10435597
Automatic Transmission · Fuel System, Gasoline
When filling the vehicle with gas, when the pump clicks off gas then overflows out of the tank and onto the ground. This is the same problem as covered in recall # 05v460000 but the vin on the vehicle is not included. There is also an ongoing defect investigation with nhtsa action # rq08005. *tr
ODI 10248970
Fuel System, Gasoline
When filling up my 2005 dodge durango, the pump will automatically shut off when full and then gas squirts/shoots out of the fill tube. This has been happening since october 2008, i checked for recalls on the chrysler website and it stated that there are no recalls for my vehicle. Although i did find a recall for my vehicle under this recall vins ending 5f500001 to 5f535219, my vin is 5f503046 which clearly falls in…
ODI 10254398
Fuel System, Gasoline
Tl*the contact owns a 2005 dodge durango. While the contact was attempting to fill the gas tank, he noticed that fuel began to pour out of the gas tank once it became full. There was no indication that the tank was full before the gasoline began to pour out. The vehicle was taken to the dealer and they stated that the filler neck needed to be replaced. The current and failure mileages were 41,200.
ODI 10245594