2005 Dodge Durango Fuel System, Gasoline Problems
- 443
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 443 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 41 records
- fuel system · 32 records
- system gasoline · 27 records
- failure mileage · 25 records
- storage tank · 25 records
- tank assembly · 25 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 177 |
| 30–60k mi | 141 |
| 100–150k mi | 42 |
| 1–30k mi | 26 |
| 150–400k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
Fuel spraying out of nozzle inlet when tank is full. Previous recall found for this problem. Possible fire hazard. *tr
ODI 10251889
Fuel System, Gasoline
Tl*the contact owns a 2005 dodge durango. The contact stated that when attempting to refuel the vehicle, fuel would spill back onto the ground because the check valve would not engage. The dealer advised the contact that the vehicle had not been included in nhtsa recall number: 05v034000 ( fuel system, gasoline:storage:tank assembly:filler pipe and cap) and offered no further assistance. The manufacturer was aware…
ODI 10429948
Fuel System, Gasoline
Fuel overfills when topping off the gas tank on my 2005 dodge durango. Since i bought it two years ago i have researched online and seen a recall but when i contacted chrysler they said mine doesn't fall within the vin number recall. This occurs everytime i put gas then i have to clean up the mess. *tr
ODI 10330035
Fuel System, Gasoline · Tank Assembly
Tl* the contact owns a 2005 dodge durango. The contact stated that the fuel tank could not be filled to capacity and fuel would be spewed from the filler neck when attempting to do so. There was a recall under nhtsa campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly) that could have been related to the failure. The manufacturer was made aware of the failure and informed the contact that the…
ODI 10426593
Fuel System, Gasoline
2005 dodge durango. Whenever the contact fills the gas tank, gasoline sprays out of the tank. The gas nozzle stops when the tank was full, but gasoline still sprayed out of the tank. And all over the floor. *tr
ODI 10246953
Fuel System, Gasoline
Tl*the contact owns a 2005 dodge durango. The contact stated that the shut off valve in her fuel tank did not function correctly. She noticed the issue on three different occasions. When placing fuel into the vehicle and using the automatic device that supports the pump handle, gasoline would spill out and splash back because the valve would not shut off. The contact felt that this was a safety hazard. She took the…
ODI 10260725
Fuel System, Gasoline
Fuel overflows when fueling my 2005 dodge durango. It used to happen once in a while but now it happens everytime i fill. I know there is a recall but my dealer says there is nothing he can do since my vin is not included. *tr
ODI 10314874
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact was refueling the vehicle as fuel began spewing from the filler tube. The vehicle was not diagnosed or repaired. There were no prior warnings of the failure. The failure mileage was 36,000 and the current mileage was 60,000.
ODI 10351793
Fuel System, Gasoline
At around 38000 miles we started having issues with the gas spilling out of the filler tube of our 2005 dodge durango when the take gets near full when refueling. At first we thought it was that particular pump, but we have had the same issue at several different gas stations. There is a recall for what seems to be the same issue, but according to the dodge web site, our 2005 durango is not part of the recall. The…
ODI 10260515
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that after refueling, the fuel would spew out from the fuel tank onto the ground due to a faulty fuel tank inlet check valve. There was a recall under nhtsa campaign id number: 09v003000 (fuel system, gasoline: storage: tank assembly) but the contact's vin was not included in the recall. The vehicle was not diagnosed or repaired. The approximate failure…
ODI 10443261
Engine And Engine Cooling · Fuel System, Gasoline
1-2 possible concerns- #1- (5.7 v.8 engine issue) as many others have complained the vehicle stalls and quits on sudden stops, and when making turn. After the engine shuts off - it can be restarted - but no engine code is generated. The dealer does not know the specific cause, but cites numerous things that it can be - wanting me to spend $$ to investigate each one and replace parts. The service department is not…
ODI 10406329
Fuel System, Gasoline · Tank Assembly
I have a fuel spit back problem w/ my 2005 dodge durango that was manufactured 05/05. It appears to be the same issue that is listed as a recall on the same make and model year vehicle that was manufactured prior to mine. When filling the tank, gas will blow back out of the filler neck with substantial force. Gasoline is speed over the side of the vehicle and ground. The first time this happened i was covered in…
ODI 10369580
Fuel System, Gasoline
When filling up our 2005 dodge durango with gas, gasoline spurts out the tank when it is full. There is a recall, but the dealer says our car is not covered. This is dangerous. How is our car not covered also? It has been happening for over a year, since the car had about 30,000 miles on it. From the recall, it is the "fuel tank filler inlet check valve". *tr
ODI 10282767
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that after refueling the fuel tank to full capacity, the fuel would spill back out. The vehicle was inspected by a dealer and they advised him that they would make adjustments to the fuel tank. The vehicle was repaired but the failure persisted. The manufacturer was contacted and they advised him to take the vehicle to a second dealer. The failure mileage…
ODI 10402459
Fuel System, Gasoline
When filling the fuel tank the gas pump will stop pumping, within seconds nearly a gallon of gas will pour out of the tank. The gas not only covers the vehicle but has sprayed me nearly hitting my eyes. The gas poured all over the grounds of the gas station requiring me to report it to the clerk. This happens every time i decide to fill my tank. It has gotten to a point in which i fear to fill my tank. I researched…
ODI 10363780
Automatic Transmission · Engine · Fuel System, Gasoline
The vehicle stalls out at low speeds. So when you are at a stop light or slow down to turn or are in a parking lot, it stalls. When this happens, you can't steer because that only works with the car running. This started right after the 3 year warranty was over and has continued through today. They also didn't fix the recall item and i have fuel spills every time i set the nozzle on automatic and it is supposed to…
ODI 10329809
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel began to leak from the vehicle through the fuel filler neck while the contact was refueling the vehicle. The failure recurred whenever the vehicle was refueled to capacity. The manufacturer was notified and the contact was told that the vehicle was not included in the recall associated with nhtsa campaign id number: 09v003000 (fuel system,…
ODI 10397110
Fuel System, Gasoline
Upon filling the gas tank, the shut off valve does not close when tank is full thus spilling fuel down the side of vehicle onto the ground. Checked recall database and there is a recall (nhtsa action # rq08005) so i contacted the manufacture and was told that my vehicle was not built in the plants in question with the recall so they told me that they were not replacing my gas tank or filler neck, but once a week…
ODI 10348584
Fuel System, Gasoline
2005 dodge durango fuel check valve problem. Gas comes back out of the fuel tank when filling the vehicle. I've been drenched with gas many times, lucky there was no static discharge in the area! I was hit the eye with fuel on more than one occasion. Chrysler knows this is a safety issue and has one recall and an extension of that recall but refuses to warranty my vehicle stating that my vin number is not effected!…
ODI 10304453
Fuel System, Gasoline
Fuel spit-back during refueling: when filling up vehicle, gas backflows out of gas tank at the end of fueling. Has happened many times at different gas stations. There is a recall on durango of same year and vintage, but my vin not included in recall and chrysler refuses to accept responsibility for design flaw. *tr
ODI 10258496
Fuel System, Gasoline
Fuel tank overflows and does not shut gas pump off when the tank is full. Everytime we fill the gas tank up, gas spews out violently all over the ground and onto the person fueling the vehicle. Seems pretty dangerous to me. Gas tank recall is partially in effect for certain vin numbers but not all.
ODI 10263094
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated took twenty minutes to fill the fuel tank and the fuel continued to spill back out from the filler tube. The manufacturer was contacted and advised that they were not aware of the type of failure. The vehicle was not repaired. The failure mileage was 50,000 and the current mileage was 80,000.
ODI 10373833
Fuel System, Gasoline · Tank Assembly
There was no incident that led to this happening. It seemed to begin for no reason. Whenever i fill my gas tank, if i do not stop the pump before the tank is full, it overflows. This happens any time i fill the tank full. A significant amount of gasoline spills when this happens. Dodge issued a recall for this exact problem on 26,000 other 2005 dodge durangos, but refuses to include my vehicle in this recall…
ODI 10297219
Fuel System, Gasoline
Gas tank spurts gas at me when filling as tank is full just before the nozzle clicks off, gas spills down the side of car and onto the ground every time the vehicle is filled up. Has been happening for 1 year. *tr
ODI 10247918
Fuel System, Gasoline
When the tank was filled with gas and the auto shut off on the dispenser engaged, gas would spew out of the vehicle under very high pressure. . The fueling problem is one that confounds me. If you allow the fuel dispenser to pump until it automatically stops, you will be greeted with a high pressure spray of fuel that will cover you and anyone standing on the opposite side of the pump. It has been this way for…
ODI 10428302