2005 Dodge Durango Fuel System, Gasoline Problems
- 443
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 443 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 41 records
- fuel system · 32 records
- system gasoline · 27 records
- failure mileage · 25 records
- storage tank · 25 records
- tank assembly · 25 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 177 |
| 30–60k mi | 141 |
| 100–150k mi | 42 |
| 1–30k mi | 26 |
| 150–400k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
Before gas nozzle clicks off. Gas sprays back out the tank and goes all over person, car, and ground. After the spray of gas the nozzle will click off
ODI 10453419
Fuel System, Gasoline
My 2005 dodge durango has a serious malfunction which causes excessive gasoline to spew from the vehicle during filling. This occurs at every fill up of the vehicle and is very difficult to prevent, even once i became aware of the issue. The gasoline exist the vehicle with considerable force the amount can vary but is typically equivalent to ~20 fl oz. Not only is this a obvious fire/explosion risk, but is also a…
ODI 10456355
Fuel System, Gasoline · Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, gasoline spewed from the filler neck without warning. The vehicle was taken to the dealer where it was advised to the contact that the fuel tank would possibly need to be replaced but a diagnosis was required. The manufacturer was made aware of the failure and stated that the vehicle was previously repaired under nhtsa campaign…
ODI 10502662
Fuel System, Gasoline
While filling up the gas tank, gas sprayed out once the tank hit full. I called dodge due to the fact there was a recall on this exact incident with the same year, make, and model. I was informed that my vin was not one of those that was included in the recall. But i was offered to go ahead and pay for the repair and then call them back and they would give me a chrysler address i could send a copy of the original…
ODI 10450756
Fuel System, Gasoline
When fueling my vehicle, the gasoline always overflows and spills out onto the ground and myself when the tank gets full. My vin # was not included in the recall and we just bought this used from a dealership. Is there any way we can get this remedied at no more cost to us? *tr
ODI 10450867
Fuel System, Gasoline
When putting fuel in the gas tank, once it fill up it shoots gas out. Not a little gas either, alot of gas. It's very dangerous. They had a recall on the 2006 through 2008 durangos but not the 2005. The recall was for check valve in the gas tank. This is extremely dangerous and i can't believe the wouldn't want to fix this before someone really gets hurt. *tr
ODI 10447181
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, fuel spilled out from the filler neck. The manufacturer was notified and stated that the vin was not included in the recall associated with nhtsa campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The dealer was not notified. The vehicle was not repaired. The failure mileage was 70,000 and…
ODI 10455924
Engine And Engine Cooling · Fuel System, Gasoline
While driving my vehicle, coming to a stop, or turning left at slow speeds 0-5 mph my engine stall without warning. No lights light up on the dash to indicate a problem. I have also noticed that rpms fluctuate (increase/decrease) while my foot is off the gas pedal. This is a daily occurrence. I first thought that i had bad fuel and put an fuel additive in the tank to hopefully resolve the problem. When the problem…
ODI 10447198
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that after refueling, a large amount of fuel would continue to emit from the filler neck and onto the ground and the contact's clothing. There was a recall associated with the failure under nhtsa campaign number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap); however the contact's vin was not included. The vehicle was taken to…
ODI 10453321
Filler Pipe And Cap · Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel would spill out from the filler neck while refueling the vehicle. The failure recurred whenever the vehicle was refueled. The vehicle was not taken to a dealer to have the failure diagnosed. The manufacturer was made aware of the failure and stated that the vehicle was not included in the recall associated with nhtsa campaign id number 05v034000…
ODI 10445624
Fuel System, Gasoline
After i bought my durango used, i brought it to fill up the gas tank. I filled up the tank, just before the gas pump shut off, there was about 1/2 gallon of gas that shot out the gas filler hose at me- i thought it was something wrong with the fuel pump at the gas station and told the gas station attendant. About one month ago i filled my fuel tank again, and again the fuel literally shot out of the filler spout at…
ODI 10445944
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. While fueling, the contact noticed fuel spill back out of the vehicle from the filler neck. The vehicle was not taken to the dealer for a diagnostic test. There were two recalls under nhtsa campaign id numbers 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) and 09v003000 (fuel system, gasoline:storage:tank assembly), that may be related to the…
ODI 10456333
Fuel System, Gasoline · Tank Assembly
Tl* the contact owns a 2005 dodge durango. The contact stated fuel spilled out of the filler neck upon refueling. The failure recurred whenever fuel was added. The vehicle was not to the dealer to have the failure diagnosed or repaired. The manufacturer was made aware of the failure and stated that the vehicle was not included in the recall associated with nhtsa campaign id number 09v003000 (fuel system,…
ODI 10445552
Fuel System, Gasoline
When i fill up the gas on my 2005 dodge durango the gas comes spraying out the filler hose all over the side of the truck and at one time the gas sprayed on my clothing also. This could be a serious issue if i happened to smoke, but it's a good thing that i don't. I contacted the dealer and they indicated that my truck is not on the list of vehicles that are included in the repair. *tr
ODI 10450489
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, fuel would spill out from the filler neck and the gas pump would inadvertently shut off. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was made aware of the failure and offered no assistance. The failure mileage was 117,000.
ODI 10443691
Fuel System, Gasoline
Fuel gushes out of the gas tank when filling up with gas. About one or two seconds after the fuel nozzle automatically shuts off because the tank is full, fuel will gush out of the tank for about another one to two seconds. I believe this is a fire hazard and a general safety concern. The dodge dealer tells me it's a stuck roll over valve and not under waranty or covered in a recall. *tt
ODI 10445942
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. While adding fuel to the vehicle, the fuel spilled out of the filler neck whenever the fuel tank was full. The vehicle was not taken to the dealer for diagnostic testing. The vehicle was not repaired. The vin was not available. The approximate failure mileage was 95,000.
ODI 10444068
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel was spilled from the fuel tank during refueling. The vehicle was not taken to the dealer. The manufacturer was contacted and they confirmed to the contact that the vin did not qualify for repairs under nhtsa campaign id number:05v034000 ( fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired. The failure…
ODI 10442711
Fuel System, Gasoline · Tank Assembly
Upon fueling my vehicle up on a regular basis; the fuel pump will shut off at time of fill up, but then a backlash of fuel occurs to be backing up in the fuel pipe and spraying/gushing out all over my vehicle. I have seen numerous and previous complaints pertaining to this issue. Why hasn't anyone realized that this is most dangerous and "all vehicles" claiming to this problem should be repaired at no cost to the…
ODI 10443179
Fuel System, Gasoline
When filling vehicle up gas overflows back out onto the vehicle and ground. *tr
ODI 10447270
Fuel System, Gasoline
FUEL SPITTING OUT OF TANK ON FILL UP. *TR
ODI 10456822
Fuel System, Gasoline
The car's fuel tank fails to shut-off, i.e. It doesn't appropriately respond to the shut-off mechanism. Gasoline overflows from the tank, sometimes in a spills out sometimes it flows out! It doesn't matter if i use the lowest setting on the gas pump or if i manually fill the tank, once full it overfills every single time i'm refueling and gas pours out of the fill spout, running down the body of the vehicle, on my…
ODI 10438875
Fuel System, Gasoline
Gas overflows and ejects when fueling. When the auto shut-off of the gas pump nozzle triggers, a considerable amount of fuel is expelled from the filler area of the vehicle. This is a reported issue covering many makes and model years of dodge vehicles. When contacting a dodge representative, she indicated that the warranty has not been extended or does not cover my vin#. She also indicated that each call is tracked…
ODI 10447668
Fuel System, Gasoline
Gas has started overflowing/spraying out when filling up. Pump stops and seconds later it happens. The first time it happened it sprayed some fuel on one of my boys who was standing by me. Thankfully, it didn't get in his eye. I first thought it was the pump but since realized its the vehicle. This seems to be fairly common issue and i have seen the two recalls on this due to the tanks inlet check valves not…
ODI 10442003
Fuel System, Gasoline
My wife and i purchased this pre-owned vehicle 10/29/2011. This happens everytime we fill the tank. The fuel handle clicks to shut of the flow of gasoline to the tank, then about a second later, the fuel begins to spew back out of the tank, draining down the exterior of the vehicle, covering the ground, and myself as i stand nearby. Each time i estimate between 1/4 & 1/2 gallon of fuel is wasted. I verified with my…
ODI 10444649