2005 Dodge Durango Fuel System, Gasoline Problems
- 443
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 443 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 41 records
- fuel system · 32 records
- system gasoline · 27 records
- failure mileage · 25 records
- storage tank · 25 records
- tank assembly · 25 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 177 |
| 30–60k mi | 141 |
| 100–150k mi | 42 |
| 1–30k mi | 26 |
| 150–400k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
I had my 2005 durango into the local dealership due to fuel shooting out of my gas tank when i filled it up with gas. I was told after diagnostic tests that it was a faulty inlet check valve and that the fuel tank needed to be replaced. I was quoted $1200 to have the tank replaced. I don't believe that i should have to pay for the tank replacement. After much online research, i see that this has been an ongoing…
ODI 10439315
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, fuel would leak out of the valve and spill. The vehicle was taken to an authorized dealer where they diagnosed the failure stating that the fuel tank needed replacement. The vehicle was not repaired. The failure mileage was 61,355 and the current mileage was 63,103.
ODI 10449413
Fuel System, Gasoline
When filling vehicle, at full shutoff, fuel blows back out the filler tube. *js
ODI 10457024
Fuel System, Gasoline
FUEL SPITS BACK WHEN ATTEMPTING TO FILL TANK. *TR
ODI 10441384
Fuel System, Gasoline
I just purchased a 2005 dodge durango. When you fill the fuel tank it overflows fuel out the filler neck spilling down the side of the vehicle and on the ground. *tr
ODI 10438182
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel spilled from the tank during refueling. The failure recurred on multiple occasions. The vehicle was taken to a private mechanic and the manufacturer was made aware of the failure. The manufacturer advised that the vehicle did not qualify for repairs under nhtsa campaign id number: 07v442000 (fuel system, gasoline: storage:tank assembly) the…
ODI 10434238
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated after adding gasoline to the fuel tank the fuel would spill out of the vehicle. The vehicle was not inspected by a dealer nor had it been repaired. The manufacturer was contacted and advised him that he was not included in nhtsa campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The failure mileage was…
ODI 10436569
Fuel System, Gasoline
While filing up with gas, when the pump clicks off when it is full gas spews out of the filler neck while the gas nozzle is still in there.. Apparently this is a widespread problem and a recall has been issued on 2006-2007 models but not 2005's like mine.. It would be nice to be able to fill my truck up with gas and not have it spew out all over the side of my truck and the ground.. *tr
ODI 10445647
Fuel System, Gasoline
When filling with gas, fuel will spill back out of the filling tube, some times when it gets full, other times it will do it all the time. Dodge has had recalls on some of these 2005 for similar issues, but for some reason ours does not fall into the range. Every time will fill fuel there is gas everywhere. *tr
ODI 10436217
Fuel System, Gasoline
When filling with gas fuel will come back out the filling spout and spill gas all over the car and ground, and sometimes the person filling it. Dodge has had recall on some of the 2005 for the same problem but ours does not fall into their range. This seems to be a big safety concern with fuel going on me, the car, and the ground. *tr
ODI 10436275
Fuel System, Gasoline
It spits gas back at you when you fill up i just read about the recall i've only owned the car for 2 year. *js
ODI 10579452
Fuel System, Gasoline
Fuel spill over when refueling on multiple dates and multiple locations of refueling. *tr
ODI 10440031
Fuel System, Gasoline
When filling up gas tank, the tank spews gas back. I received a recall notice when it first came out in 2009. I did have my vehicle checked at that time (then i was not having problems.) the dealership said it was taken care of. Now, my durango is having problems with it. The tank even spews gas when filling slowly. *tr
ODI 10434934
Fuel System, Gasoline
Tl* the contact 2005 dodge durango. The contact stated that fuel began to spill out from the filler neck while refueling. The vehicle was not taken to have the failure diagnosed. The manufacturer was made aware of the failure and informed the contact that the vehicle was not included in the recall associated with nhtsa campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap).…
ODI 10436599
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling the vehicle, fuel escaped out of the filler tank and splashed on the contact. The contact referenced a nhtsa campaign i.d. Number 09v003000 (fuel system, gasoline:storage:tank assembly) and called the dealer. The dealer informed the contact the vehicle was not included in the recall. The manufacturer was not contacted. The failure…
ODI 10436210
Fuel System, Gasoline
When i fill up with gasoline, if i do not stop 2 gallons shy of a fill or slow it to a trickle, it will spew about a 1/2 gallon of gasoline down the side of the vehicle. I have done an online search and found chrysler is recalling close to 25,000 2005 dodge durango vehicles as the fuel tank filler tube inlet check valve may not fully close at the end of refueling. This could allow some fuel to escape from the…
ODI 10452233
Fuel System, Gasoline
When fueling, approx. 1 to 2 quarts of gas burps out of the fuel filler tube. This occurs regardless of how fast or slow the fuel is dispensed. Seems to not be venting properly. I see daimlerchrysler recall # e01 and h45 have been issued, however my manufacture dates do not fall within range. Can my vin info be checked and/or are there any other options available to have this repaired by the dealer without cost? *tr
ODI 10440330
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, fuel leaked from underneath the vehicle. The fuel cap and engine warning light also illuminated on the instrument panel. The vehicle was not taken to the dealer for a diagnostic test. The contact replaced the fuel cap, but the failure continued. There was a recall under nhtsa campaign id number 05v034000 (fuel system,…
ODI 10454658
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, fuel spilled to the ground abnormally. The manufacturer was contacted and denied assistance repairs because the vehicle was not included in nhtsa campaign id number: 09v003000 (fuel system, gasoline: storage: tank assembly). The vehicle was not repaired. The failure mileage was 88,000 and the current mileage was 89,000.
ODI 10435644
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated when adding fuel to the vehicle, gasoline was spilling out of the fuel tank. The contact took the vehicle to the dealer to be inspected and was told that nhtsa recall campaign id number: 05v034000 (fuel system, gasoline: storage: tank assembly: filler pipe and cap) was related to the failure; however, the vehicle was not included. The current mileage was…
ODI 10427553
Fuel System, Gasoline
When adding gas to the vehicle the gas tank spits the gas out. *tt
ODI 10425852
Engine · Fuel System, Gasoline
I have seen lots of complaints about this same issue online as well as 2 open and closed investigations on this website! While driving my 2005 dodge durango it will shut off on its own, steering is impossible at this point. It use to happen a lot to me. Normally it would always happen pulling in or backing out of my driveway. But i live in rural wv and we have mountains and curvy roads. Once i was driving about…
ODI 10544610
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel would spill from the fuel tank when full. The contact referenced nhtsa campaign id number: 09v003000 (fuel system gasoline: storage tank assembly) but was advised by the dealer that the vehicle was not included in the recall. The failure mileage was 129,000.
ODI 10424234
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel spilled from the filler neck while refueling. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was made aware of the failure and the contact was informed that the vehicle was not included in nhtsa campaign id numbers: 09v003000 (fuel system, gasoline:storage:tank assembly) or 05v034000 (fuel system,…
ODI 10446397
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel emitted from the fuel tank while refueling. The vehicle was taken to the dealer and the manufacturer was contacted, and confirmed that the vin failed to qualify for repairs under nhtsa campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly). The vehicle was not repaired. The failure mileage was 68,000 and the current mileage…
ODI 10451292