2005 Dodge Durango Fuel System, Gasoline Problems
- 443
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 443 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 41 records
- fuel system · 32 records
- system gasoline · 27 records
- failure mileage · 25 records
- storage tank · 25 records
- tank assembly · 25 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 177 |
| 30–60k mi | 141 |
| 100–150k mi | 42 |
| 1–30k mi | 26 |
| 150–400k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
At the end of fueling fuel gushes back from fuel filler receptical. This happens using pump set for auto cut off or manual operation. This occurs every time fueling is completed without stopping short of auto fuel cut off by the pump. This to me is a very serious safety issue as any source of ignition could cause a very serious accident. I have found many complaints about this problem with many different durango…
ODI 10445998
Fuel System, Gasoline
My 2005 dodge durango began spitting gas back out after the pump has clicked off. Approximately, 1/2 gallon is wasted, it on lands on the car, ground and myself. This occurs each and every time the car is fueled. Dodge has a recall on the gasoline:storage:tank assembly recall for 2005 dodge durango's but my vin is not included. I have called dodge and they have informed me that i must pay a diagnostic fee,…
ODI 10362694
Fuel System, Gasoline
The fuel filler spits fuel back out of the tank while filling causing an overflow onto the truck, the ground, and the person filling the fuel tank. Dodge has issued selective recalls for this same issue, but apparently there aren't enough complaints about my particular year to do anything about the problem. (according to dodge customer service) there are recalls for durango's both newer and older than mine for the…
ODI 10452173
Fuel System, Gasoline
2005 dodge durango (80,000) miles. Gas over flows from gas tank take when filling. Has happened numerous times. A real fire hazard ! 2005 dodge durango (34,000) miles. Gas over flows from gas tank take when filling. Has happened numerous times. A real fire hazard ! *tr
ODI 10349050
Fuel System, Gasoline
2005 dodge durango (34,000) miles. Gas over flows from gas tank take when filling. Has happened numerous times. A real fire hazard ! *tr
ODI 10347832
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that when she attempted to refuel the vehicle, gasoline would spill back out from the filler neck. The manufacturer was made aware of the failure but offered no assistance. No repairs were performed. The current mileage was 89,311. The failure mileage was unknown.
ODI 10422820
Fuel System, Gasoline · Tank Assembly
Tl* the contact owns a 2005 dodge durango. The contact stated that as he refueled the vehicle, gasoline began spewing back from the filler tube once the fuel tank was full. The vehicle was taken to the dealer who diagnosed that the fuel valve was defective and needed to be replaced. The manufacturer was contacted but did not offer any assistance stating that the vehicle was not included in the recall associated with…
ODI 10390429
Fuel System, Gasoline
I have a 2005 dodge durango limited. I have a safety issue on the vehicle when i'm fueling the vehicle up and the gas pump safety switch clicks and shuts off the pump when the tank is full, fuel spews back out of the tank. This fuel spray can fly 2 to 3 feet in any direction depending on the fuel nozzle used. I called about this safety issue to a local dodge dealership and they told me my durango is not included in…
1 injury
ODI 10350544
Fuel System, Gasoline
Fuel sometimes sprays out from the neck of tank (where pump goes into car) when fueling is complete if tank is pumped until full. I bought the vehicle used from a dealership in september 2009 and have had the problem about 6-12 times in the past year (i have added about 8,000 miles to the car over this time). I contacted the dealer as well was chrysler, who both stated that the vehicle is not covered under the…
ODI 10346818
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact was refueling the vehicle as approximately one half gallon of gasoline began to spew back out from the filler tube and onto the contact. The contact stated that the failure would occur whenever the vehicle was refueled. The contact referenced nhtsa campaign id number: 05v034000 (fuel system, gasoline: storage: tank assembly: filler pipe and cap) and stated that…
ODI 10356158
Fuel System, Gasoline
When i fill my 2005 dodge durango fuel tank, i get a splash back of fuel. This happens more than 90 percent of the time when i fill my tank. It does not occur when i refuel without filling the tank. I am aware of a recall(dated 2009-01-08) that covered this issue for 2005 dodge durango, but i was advised by my local dealer and by chrysler customer service that my vin was not included. I am told repair will cost me…
ODI 10342216
Filler Pipe And Cap · Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, fuel began to spill out from the fuel filler neck. A dealer was notified and advised the contact to bring the vehicle in for a diagnosis. The vehicle was not yet taken in for diagnosis. The manufacturer was then notified, and the contact was informed that the recall associated with nhtsa campaign id number 05v034000 (fuel system,…
ODI 10411534
Fuel System, Gasoline
Tl*the contact owns a 2005 dodge durango. The contact stated that when he added gasoline to the fuel tank that the fuel would spill out of the tank. The vehicle was not inspected by a dealer since they would have to drop the tank. They also advised him that his vin was not included in the recall nhtsa campaign id number (09v003000-fuel system, gasoline:storage:tank assembly). The vehicle had not been repaired. The…
ODI 10378749
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact was refueling the vehicle when fuel began to spew back out from the filler tube. The failure began as an intermittent issue but soon progressed to the point where the failure occurred whenever the contact was refueling the vehicle. The manufacturer was notified and the contact was told that the vehicle was not included in the recall associated with nhtsa…
ODI 10377902
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, gasoline would immediately spill back out from the fuel tank. The failure recurred whenever the vehicle was refueled. The vehicle was neither inspected nor repaired for the failure. The dealer stated that the vehicle was not included in either recall associated with the failure (nhtsa campaign id numbers: 05v034000 (fuel…
ODI 10392852
Fuel System, Gasoline
2005 dodge durango: starting at about 80,000 miles, or about 6 months ago, whenever we topped off the fuel tank, gasoline would spurt back up out of the filler tube at the end of the fill when the pump kicked off. This is still happening every time we fill up the tank. Filling up our other vehicle at the same pump does not reproduce the problem. Filling up our durango at any pump reliably reproduces the problem. *tr
ODI 10339106
Fuel System, Gasoline
Fuel filler neck on vehicle, sprays gasoline during fill up- about 1- 2 cups each time. Dodge dealer refuses to fix under the 2 recalls- chrysler has basically said tough. This is a dangerous and recurring problem. *tr
ODI 10336562
Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact stated that the vehicle was leaking fuel. The contact took the vehicle to the dealer and was told that the leak was coming from the inlet check valve. The contact inquired of nhtsa campaign id number: 09v003000 (fuel system, gasoline: storage: tank assembly) but was advised that the vehicle was not included in the recall. The failure mileage was 71,000 and the…
ODI 10448312
Fuel System, Gasoline
My 2005 dodge durangos fuel tank spews fuel all over the place when i am finishing a fill up. This happens everytime that i fill my tank full. I see that a recall was issued for 2005 dodge durangos for this exact problem, but the recall doesn't include my vin. If a recall was issued for this problem it should take care of every affected vehicle. It is not safe at all! *tr
ODI 10332053
Fuel System, Gasoline
Every time i fill up my car at the gas station, it overflows. It's a 2005 dodge durango. I was told there was a recall associated with this problem but never received a notice about it. The problem started about 3 or 4 months ago. *tr
ODI 10353929
Fuel System, Gasoline
Any time i fill my gas tank up on my 2005 dodge durango when the tank gets close to full the fuel doesn't stop and it spills all over the side of the truck ground and myself. I t has happened at multiple gas stations so i have eliminated the possibility that it is the pump. Gas station attendants get upset whenever you spill gasoline because of the cleanup procedure and i am also upset as it's gas i have paid for…
ODI 10332338
Fuel System, Gasoline · Tank Assembly
I own a 2005 dodge durango vin [xxx]. When refueling the vehicle, fuel over flows onto the vehicle and ground at the end of the fueling process every time you fill the tank. My research has shown there was a recall under nhtsa campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly). The manufacturer was contacted and advised that the vin was not included in the recall and that i would need to…
ODI 10389830
Filler Pipe And Cap · Fuel System, Gasoline · Tank Assembly
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel spilled out from the filler neck while refueling. The vehicle was taken to the dealer for a diagnosis. The dealer stated that they needed to replace the fuel tank inlet check valve. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was not included in the recall associated with nhtsa campaign id number:…
ODI 10468016
Engine And Engine Cooling · Fuel System, Gasoline
Tl* the contact owns a 2005 dodge durango. The contact was driving approximately 20 mph and the engine stalled without prior warning. The vehicle restarted and the contact was able to continue driving. The failure occurred intermittently. The vehicle was taken to an independent mechanic for diagnostic testing; however, they were unable to detect a trouble code. The failure continued to occur. In addition, whenever…
ODI 10430164
Fuel System, Gasoline
Gas overflows on my 2005 dodge durango when filling up. Happens every time. Have gone to local dealership and contacted customer service online and both have said my vin# doesn't fall under their previous recall. *tr
ODI 10329067