2005 Dodge Durango Fuel/Propulsion System Problems
- 186
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 186 stored complaint records:
- 1 indicate a crash
- 3 indicate injury
- 1 indicate fire
What owners report
- fuel tank · 43 records
- filler neck · 24 records
- fuel system · 20 records
- failure mileage · 20 records
- check valve · 17 records
- fuel filler · 15 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 55 |
| 100–150k mi | 53 |
| 150–400k mi | 23 |
| 30–60k mi | 20 |
| 1–30k mi | 9 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, fuel would overflow abnormally with pressure, causing the contact to become saturated with gasoline. The failure recurred several times. The vehicle was not taken to the dealer for inspection or repair. The manufacturer was made aware of the failure and advised the contact that the vehicle was not included in nhtsa…
ODI 10471490
Fuel/Propulsion System
Fuel overflows out of vehicle when trying to fill tank. *tr
ODI 10466673
Fuel/Propulsion System
When filling the gas tank, gas shoots back out when the tank is full. This happens each time i refuel. *tr
ODI 10464525
Fuel/Propulsion System
Large amount of fuel spits out of fuel inlet tube at the end of refueling. Existing recall that address this issue does not cover enough vins.
ODI 11066958
Fuel/Propulsion System
When gassing the vehicle, gas tank overflows as the tank fillas or when i stop adding gas. *tr
ODI 10463633
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that while driving 30 mph, the check engine warning light illuminated on the instrument panel. The vehicle was taken to a dealer for inspection where they advised the contact that the fuel cap needed to be replaced. The vehicle was repaired but the failure recurred. The manufacturer was notified and also advised that the fuel cap needed to be replaced.…
ODI 10489255
Fuel/Propulsion System
I asked the gas attendant to fill up the tank. After about half a minute or so, gas sprayed out of the tank. I would estimate half a gallon of gas or so was sprayed out onto the car and ground. At first i thought it was the gas pump nozzle. Did fill ups at three different gas stations and same result. I called the dealership and the mechanic said that only the 4.7s are being recalled not the 5.7s for the gas tank's…
ODI 10467891
Fuel/Propulsion System
Fuel overflows when you fill the tank up. Gas kicks back smell gas fumes while parked some times. Dealer says its not covered. But there is a recall for fuel tank check valve. Vehicle was already corrected once for same issue. Problem reoccurred. *js
ODI 10598346
Body · Fuel/Propulsion System
I stopped at the gas station to put gas in my 2005 durango. When it was full the gas sprayed out all over my leg and boots. When i looked for a recall there was one but not for my vin. Because of this my finder is rusting out and ever durango i see the same make as mine has the same rust spot. I don't understand why it isn't part of the recall. The gas overflow and the rust spot.
ODI 11031880
Fuel/Propulsion System
I am the owner of a 2005 dodge durango. We are having an issue were the fuel will not shut off at the pump. There is a recall for that year, but surprisingly enough our vin # does not fall under the recall. We had the fuel tank replaced in january of 2008 under warranty for the same issue. Obviously there is an issue with the tanks and their manufacturing process. Concern is the tank was replaced with a defective…
ODI 10485901
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that after refueling, fuel spew back out of the filler neck. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure but did not offer any assistance. The vehicle was not repaired. The failure mileage was 68,000 and the current mileage was 69,714.
ODI 10486054
Fuel/Propulsion System
When i am filling up my gas tank at a gas station, the pump will kick off when full and a few seconds after you can hear fuel rushing up the tube and then sprays out all over the side of the car and on the ground. The side of my vehicle is starting to rust because of this and i have been held responsible to fuel cleanup at a few gas stations. Its my understanding there was a recall issued on some vehicles but since…
ODI 10470514
Fuel/Propulsion System
Multiple occassions different gas stations - when filling the gas tank and removing nozzle the gas spills out in pretty large volume. Happened on last 4 occasions. Other durango's same model year are seeing the same thing. Not safe. *tr
ODI 10465522
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, the fuel tank filler tube inlet check valve did not fully close, allowing fuel to escape from the vehicle. The manufacturer was contacted and advised that the vehicle was not included in nhtsa campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly). The vehicle was not repaired. The approximate failure mileage was…
ODI 10483148
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that whenever dispensing fuel into the fuel tank, the fuel would overflow from the filler neck onto the ground. There was a recall associated with nhtsa campaign id number 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap); however the vin was not included. The manufacturer was notified of the problem. The vehicle had not been…
ODI 10465383
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that the filler tube inlet would not close after the vehicle was refueled with gasoline, causing fuel to leak. The vehicle was taken to the dealer who informed the contact that the vehicle was not included in nhtsa campaign id number: 05v034000 (fuel system, gasoline: storage: tank assembly: filler pipe and cap). The manufacturer was notified of the issue…
ODI 10464443
Fuel/Propulsion System
While filling fuel tank, the gas pump stopped but fuel shot out of the filler tube spilling on the ground. This has happened on several occasions and does not matter how fast the fuel goes in. *tr
ODI 10479857
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, gasoline spewed from the filler neck without warning. The vehicle was taken to the dealer where the vehicle was inspected but not repaired. The contact was advised that the fuel tank would need replacing. The manufacturer was made aware of the failure and stated that the vehicle was not listed under nhtsa campaign number: 09v003000…
ODI 10546478
Fuel/Propulsion System
When we filled up at the gas station the car didn't plug itself when it got full--gas ran out all over my hands, car and ground. This has happened at least 4 times in the last year. The dealership tells me that my vin is not one of the cars registered for a recall for the fuel tank inlet check valve--which it should be! This is a fire waiting to happen!!!! *tt
ODI 10459139
Fuel/Propulsion System
When refueling the vehicle at the gas pump and the tank becomes full and the gas pump clicks fuel spews out of the gas tank opening.
ODI 11101588
Fuel/Propulsion System
When filling up the vehicle with gasoline the filler tube does not close and gasoline comes up and out of the tube. I was informed that numerous complaints have been issued, as well as, two recalls, but since my vehicle was manufactured in 3-2005 it is not covered. As this has the potential for injury and fire this recall should be expanded as obviously it affects more vehicles then in the past recall notices. *tr
ODI 10475620
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. After refueling the vehicle, fuel spewed out of the filler neck. The failure recurred multiple times. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 50,000.
ODI 10702184
Fuel System, Gasoline · Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling, gasoline spewed from the filler neck without warning. The vehicle was taken to the dealer where it was advised to the contact that the fuel tank would possibly need to be replaced but a diagnosis was required. The manufacturer was made aware of the failure and stated that the vehicle was previously repaired under nhtsa campaign…
ODI 10502662
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that the vehicle was repaired according to nhtsa campaign number: 09v003000 (fuel system, gasoline), but the failure recurred. Upon re-fueling the vehicle, the fuel tank filler tube inlet check valve would not fully close or the filler neck may have fractured and caused a leakage. The dealer stated that the contact was to re-fuel the vehicle to test the…
ODI 10732804
Fuel/Propulsion System
When the gas tank is being filled there is no longer a shut off that occurs thus gas overflows on car, person and gas station floor. *tr
ODI 10469590