2006 Dodge Durango Fuel System, Gasoline Problems
- 372
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 372 stored complaint records:
- 0 indicate a crash
- 5 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 38 records
- filler neck · 24 records
- filling tank · 22 records
- every fill · 20 records
- failure mileage · 20 records
- fill tank · 19 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 167 |
| 60–100k mi | 121 |
| 1–30k mi | 35 |
| 100–150k mi | 17 |
| 150–400k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
When fueling vehicle, a large amount of gas overflowed filler tube after pump shutoff. Gas sprayed approximately 3 feet, covering fueler and pump. *tt
ODI 10446040
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that while refueling the vehicle, fuel spilled from the fuel tank. The vehicle was taken to the dealer where it was confirmed that the fuel tank needed to be replaced. The manufacturer was contacted but the vehicle was not repaired. The vin was unavailable. The failure mileage was 65,000 and the current mileage was 65,300.
ODI 10450539
Fuel System, Gasoline
When i go to the gas station to put gas in i can only put a 1.50 in and the pump kick off and gas come out i wait for a little bite and it will take 2.00 and tit does the same thing again it come right back out. *tr
ODI 10443142
Fuel System, Gasoline
You can not fill the gas tank over 3/4 full as it will result in a massive fuel spillage out of the filler neck. The backwash out of the tank will cover you and the side of the car and you with fuel. It does not matter what kind of fuel station is filling it happens every time. If there was any kind of spark a large fire would occur. *tr
ODI 10558285
Fuel System, Gasoline
Vehicle spots has everywhere when putting gas in. Can not put over 3/4 tank in or a least a gallon is coming back on your feet & ground. The paint is also rusting under the gas cap now due to this issue. I have noticed that this is an issue with this model year and there are numerous online complaints. The 2005. Was recalled due to the same issue. This year also should be recalled and fixed! *tr
ODI 10575435
Body · Fuel System, Gasoline
Fuel tank overflows during fill up. Spilling tons of gas. Because of the overflow there is a lot of rust forming on body were gas tank is. I have taken it to body shop to see about getting the rust fixed but said would have to replace that whole area because rust ate through. To be honest i thought i was doing something wrong when filling up at the gas station or something was wrong with the pump for a long time…
ODI 10515976
Fuel System, Gasoline
We purchased this vehicle from a used car dealership 12-31-2111 after driving it to the gas station to fill it up i encountered a problem . The fuel pump shut off when the durango was full but immediately after the gas came spraying out of the tank but the pump was off . It sprayed gas all over side of the vehicle and all over me and my clothes it was awful. This has happened 3 times so far and we have owned the…
ODI 10444446
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that when she attempted tore fuel the vehicle, the pump would shut off and gas would spew back out onto from the filler neck valve. The contact referenced nhtsa campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) but did not confirm if the vehicle was included in the recall. The vehicle was taken to the dealer…
ODI 10444445
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that fuel would spill out from the filler neck while refueling. The dealer informed the contact that the check valve failed and advised him to replace the fuel tank. The manufacturer did not offer any assistance since the vin was not included in the recall associated with nhtsa campaign id number 05v034000 ( fuel system, gasoline:storage:tank…
ODI 10445438
Fuel System, Gasoline
There is a known issue of fuel overflow with 2nd generation dodge durango that dodge refuses to issue a safety recall to fix. At the conclusion of refueling approximately 0.25 gal will gurgle to forcefully eject itself from the fuel filler neck of the durango. Spilling fuel every fill up is a personal safety and environmental pollution concern which needs to be addressed.…
ODI 10441198
Fuel System, Gasoline
Was filling up 06 dodge durango and fuel will flow out violently after the fuel nozzle shut off was activated. There was about quart or more fuel splashed out of the fuel nozzle of the car. There is even a rust spot on the driver side rear quarter panel under the fuel nozzle on the car where fuel has eating at the metal. This is a very dangerous situation and can be deadly. This should be taken seriously. *tr
ODI 10441121
Fuel System, Gasoline
My 2006 dodge durango slt over fills every time it is filled up. Gas will shoot out 12-15 inches in all directions sometimes. This started happening at around 60 thousand miles. *tr
ODI 10441367
Fuel System, Gasoline
Went to fill durango up two days after purchased used. The pump shut off automatically and sprayed approx. One liter of gas on my hand, sleeve, right leg, right shoe, and the fender/bumper of the vehicle. This is a serious safety concern and there is no warning from dodge that this may occur. This was a recall on 2005's and dodge representatives told me when i asked about an assist, "if it was a recall before and…
ODI 10441090
Fuel System, Gasoline
Filling up with gas the nozzle clicks and a few seconds later gas will shoot out of the tank. *tr
ODI 10575419
Delivery · Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that while refueling, gasoline began spewing from the filler neck and the fuel pump would not shut off. The contact stated that the failure recurred several times. The vehicle was not taken to a dealer for inspection. The vehicle was not repaired. The manufacturer was notified of the failure and stated that there were no recalls for the vehicle. The…
ODI 10488961
Fuel System, Gasoline
When filling up with gasoline, upon the fuel pump turning off, the durango's fuel tank will spray gasoline back out to the individual filling up, and leak fuel all over the vehicle and ground. This happens every time i fill up, regardless of filling station. This is documented in countless forums and videos online. The 2005 durango has a recall for this as dodge recognized the risk of a vehicle or fuel station fire.…
ODI 10447486
Fuel System, Gasoline
Fuel overspill when gas station pump reaches auto shut-off. After fuel tank replaced, gas station pump cuts out every gallon to gallon & a half when attempting to fill tank. *tr
ODI 10442211
Fuel System, Gasoline
During fueling operations the vehicles fuel tank was almost full which triggered the fuel pump to shut off, and then immediately fuel began rushing out of the fueling nozzle of the vehicle getting on the side of the vehicle, my hand, foot and the ground. This has happened more than 60 times since owning the vehicle in 2006, and now happens every time i fill the tank to full. There was a similar problem with the 2005…
ODI 10438037
Fuel System, Gasoline
I have a 5.7 hemi and the problem just started with fuel splashing out after a fill up, pump clicks off, remove the fuel nozzle and out of the vehicle fuel fill gas shoots out and all over. Maybe a pint or quart of gas, hard to measure when it's all over you, the ground and car..... I also called my dodge dealer and my vin was not part of the recall. *kb
ODI 10441595
Fuel System, Gasoline
I have filled up my vehicle on multiple occasions since i have purchased this vehicle used. Every time i fill it up the gas tank bubbles and is shoots a decent amount of gas out of the tank onto the ground and down the side of my car. This causes my car to smell like gasoline and leaves a puddle of approx 1 cup of gas on the ground. At first i thought it was a particular gas stations nozzle, but after going to…
ODI 10438493
Fuel System, Gasoline
Bought 2006 dodge durango used and pulled out of dealership to get gas and filled up and gas shot everywhere. Very dangerous and fire hazard. Problem filling ever time i get gas. A problem that needs immediate attention before someone gets hurt. *tr
ODI 10436912
Fuel System, Gasoline
When filling gas tank after nozzle clicks off within second a gush of fuel shoots out of tank. We are only owner of vehicle and this has happened for years. We had fuel tank replaced once and it continues to happen and is getting really bad again. Today so much fuel shot out that if someone was standing there it would of soaked them. It was so obvious and so much that the other people at the station saw it and were…
ODI 10433951
Fuel System, Gasoline
Every time i fill up with gas it erupts back out of the tank. The local dealer says it is the fuel tank filler check valve. This is located inside the fuel tank. The solution is to replace the fuel tank. Dodge did a recall on the 2005 durango but not the 2006 durango. $900 for the part plus labor. *tr
ODI 10451492
Fuel System, Gasoline
After filling vehicle with fuel gas will shoot out of intake area. Approximately 1/4 to 1/2 gallon. *kb
ODI 10446388
Fuel System, Gasoline
When filling the vehicle up with gas, the sensor to stop the gas pump does not work. Result is an overflow of about .5 gallon of gas to spill on the exterior of the vehical and ground below.
ODI 10444416