2006 Dodge Durango Fuel/Propulsion System Problems
- 143
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 143 stored complaint records:
- 0 indicate a crash
- 1 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 27 records
- fill tank · 23 records
- filling tank · 15 records
- onto ground · 15 records
- every fill · 15 records
- filler neck · 15 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 49 |
| 100–150k mi | 28 |
| 30–60k mi | 26 |
| 1–30k mi | 12 |
| 150–400k mi | 8 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
The gas tank overfills when filling the tank. When i fill the tank at the gas station the pump will not shut off until after the tank overflows onto the vehicle and the ground.
ODI 11291185
Fuel/Propulsion System
Tl* the contact owns a 2006 dodge durango. While refueling the vehicle at a fuel station, the pump shut off and the fuel rapidly spewed out all over the ground. The contact stated that the failure recurred twice. The vehicle was not diagnosed or repaired. The dealer and manufacturer were not notified of the failure. The approximate failure mileage was 145,000.
ODI 11221172
Fuel/Propulsion System
Every time i go to fill the tank while the car is in park at a gas station the pump will stop cause the truck is full and then the truck will spit fuel back out.
ODI 11194839
Fuel/Propulsion System
Every time i go to fill my 2006 dodge durango slt it will fill and the gas pump will stop and turn off but then the truck will spit fuel back out. The vehicle was in park and a gas station everytime. Please email me @ [xxx] or call @ [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tt
ODI 11194838
Fuel/Propulsion System
Tl* the contact owns a 2006 dodge durango. While the contact was pumping fuel into the vehicle, the fuel sensor on the tank did not work. As a result, fuel overflowed from the fuel tank opening. The contact stated that the failure began on approximately june 15, 2018. The manufacturer and dealer were not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 190,000.
ODI 11193173
Fuel/Propulsion System
When filling up on gasoline it will over flow out of the vehicle through the filler tube. Similar to the other recall possibly the same issue that affected 2005 models
ODI 11181231
Fuel/Propulsion System
FUEL OVERFLOWS WHEN FILLING UP
ODI 11149506
Fuel/Propulsion System
Leaking large amounts of fuel overflow when at gas station filling up gas tank.
ODI 11149498
Fuel/Propulsion System
FUEL GUSHING OUT WHEN FILLING UP TANK.
ODI 11149494
Fuel/Propulsion System
FUEL SPILLS OUT WHEN FUELING EVERY TIME.
ODI 11149488
Fuel/Propulsion System
Leaking massive fuel on fill ups each time. Done this forever. Rusting in area where happens badly.
ODI 11149491
Fuel/Propulsion System
There was indeed a recall for the 2005 and 2006 model years of my vehicle from chrysler for a fuel safety issue of massive amounts of fuel spilling out of the tank during fuel ups. They acknowledge, the recall was cut off exactly one day prior to this particular vehicle's manufacturing date. The part identified was a fault with the fuel inlet check valve. Dodge identified the only recourse for this vehicle is to…
ODI 11132724
Fuel/Propulsion System
During fuel up it over spills out a lot of fuel each time at the gas station. I see there were recalls for the prior years of the same vehicle. This problem has identical symptoms.
ODI 11131024
Body · Fuel/Propulsion System
Hil adding gas, the fuel overflow does not shut off when full. Gas spills out of the tube and runs down the side of the durango and onto the ground. There is considerable rusting under the fill tube. I purchased thsi vehicle 4 years ago and it has always done this. The rust area had been repaired prior to me purchasing so i am assuming this has happened before my ownership as well.
ODI 11065495
Fuel/Propulsion System
My car has a very bad hesitation upon acceleration and shutters when the pedal is to the floor. The code i'm getting is a dealer part only and i've found that 4 out of five dodge durango or chrysler aspen have had this issue. This has been a very expensive trial and error process. My sister who owns a 2008 aspen just replaced the same part i need to replace for almost 1,000 dollars and that's not the only time i've…
ODI 11052436
Electrical System · Fuel/Propulsion System
2006 dodge durango ecm fail 2006 dodge durango fuel overspills
ODI 11019411
Fuel/Propulsion System
The fuel tank filler tube inlet check valve is not fully closing at the end of refueling. This allows some fuel to escape from the vehicle filler neck. Consequencesfuel leakage in the presence of an ignition source can result in a fire. When refueling at a gas station
ODI 10945314
Fuel/Propulsion System
When fueling the gas tank will burp out gas when it is full and spray all over you.
ODI 10946660
Fuel/Propulsion System
This incident has occured twice on me since purchase of a used 2006 durango. On 11/20/16 i stop at gas station to fill the durango up with gas. I place the nozzel into gas tank select my grade of gas & put nozzle into auto fill. Upon tank becoming full of gas the gas nozzel shut off & afterwards gas began to spewed out of tank, sometime with high pressure & sometimes in low pressure spray. Gas continued to flow out…
ODI 10927116
Fuel/Propulsion System
I can not put gas in the tank. The fuel neck was replaced twice because of the recall. That is not my problem. Very little gas goes in when you engage the fuel pump at the gas station maybe 10 or 12 ounces the the pump clicks off and stops filling. I try it again then slowly put gas in and the fill neck gets full because the tank will not let the gas in and it spits out the fill opening and on the car and ground. I…
ODI 10937357
Fuel/Propulsion System
Tl* the contact owns a 2006 dodge durango. While the vehicle was stationary, the fuel tank spilled fuel onto the ground. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 117,000.
ODI 10924278
Engine · Fuel/Propulsion System · Power Train
I am experiencing a problem with the engine cutting off in full drive situations, all of sudden my check engine light pops up and that's my pre warning that my truck is getting ready to turn off. It is hesitant sometimes and waits till i am complete stop or sometimes it totally shuts down while driving in traffic. Very scary.
ODI 10898881
Fuel/Propulsion System
The fuel tank check valve has completely failed just like thousands of other durangos. There is significant (12-16 ounces) gas blowback when the fuel reaches a near full level during refueling. I have tried stopping the pump several times to allow the fuel to settle, different brands of gas and different filler handle positions. The only thing that can prevent this is not filling the tank more than 3/4 full.
ODI 10895462
Fuel/Propulsion System
When filling with fuel to full capacity, it spews fuel out on my clothes and shoes and down the side of the durango. It does not matter what fuel station i go to, it does the same thing.
ODI 10882471
Fuel/Propulsion System
When filling the fuel tank gas spews out the fill port once the tank is full
ODI 10870245