2006 Dodge Durango Fuel System, Gasoline Problems
- 372
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 372 stored complaint records:
- 0 indicate a crash
- 5 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 38 records
- filler neck · 24 records
- filling tank · 22 records
- every fill · 20 records
- failure mileage · 20 records
- fill tank · 19 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 167 |
| 60–100k mi | 121 |
| 1–30k mi | 35 |
| 100–150k mi | 17 |
| 150–400k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated while refueling the vehicle, fuel spewed back out from the filler neck spilling onto the contact. The manufacturer was contacted and advised that they were aware of the failure but because there was not a recall, they were not willing to assist with repairs. The vehicle was taken to the dealer who performed a diagnostic that located the failure at the…
ODI 10386966
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that fuel spilled from the filler neck while refueling. The failure recurred whenever the fuel tank was filled to capacity. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
ODI 10450534
Fuel System, Gasoline
When filling 2006 durango with fuel the fuel will spew back out of filler. *tr
ODI 10390018
Fuel System, Gasoline
A large amount of fuel sprays out of fuel filler when gasoline pump shuts off at tank full. *tr
ODI 10386238
Fuel System, Gasoline
Gas overflows after fuel bump stops during every fill up. *tr
ODI 10574897
Fuel System, Gasoline
When i fill my gas tank on my 2006 dodge durango the pump shuts off then gasoline spills out and all over the vehicle and ground. I have had this happen since i bought the vehicle and it happens every time at any gas station. *tr
ODI 10390449
Fuel System, Gasoline
Fuel spit-back- whether we fill it on the lowest setting on the gas pump or if we manually fill it using as little pressure as possible it overfills every single time and gas pours from the fill spout down the body of the vehicle, on my hands clothes and on the ground. I have had to go home and change clothes after trying to fill the car with gas.
ODI 10388613
Fuel System, Gasoline
2006 dodge durango gushes fuel out of tank during filing. This is a serious problem and dangerous situation that is being ignored by the manufacturer. Dealer and manufacturer expect owners to pay for tank replacement although 2005 models had the same issue and had recall. Chrysler needs to recall and cover all years that have this problem before someone is injured or killed! *tr
ODI 10386117
Fuel System, Gasoline
Fuel overflows while filling tank at every fill-up, and at every gas station or pump. Started at approx. 45,000 miles. Called dealer and they said that hadn't heard of this problem in the 2006 model, only the 2005. Have an appt. To check out. Luckily i have the extended warranty, which has come in use twice now! *tr
ODI 10392892
Fuel System, Gasoline
When refueling vehicle the gas will exit tank with force, spilling gas on ground, vehicle and operator. Potential explosion hazard, environmental damage, chemical burns and explosion injury. This started occurring at around 75,000 miles and happens at every fill up when topping off. *tr
ODI 10394137
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that when he attempted to add more than a half gallon of fuel to the vehicle it would spill onto the ground. The dealer advised the contact that his vehicle was not included in any recalls. The manufacturer was aware of the failure. The vehicle was taken to a private mechanic who inspected the vehicle and informed the contact of the repairs; however, the…
ODI 10420142
Fuel System, Gasoline
Dangerous fuel safety problem with 2006 dodge durango ! When filling gas tank, the pump automatically shuts off and approximately 1-2 pints of gas shoots out of the filler nozzle. It doesn't matter what brand of gas pump, or how much fuel is dispensed. This always happens when filling up. *tr
ODI 10408502
Fuel System, Gasoline
Faulty valve on fuel tank does not prevent gasoline from spilling during refill. *tr
ODI 10394269
Filler Pipe And Cap · Fuel System, Gasoline
Gas spills from vehicle when we stop refilling the vehicle. It surges from the tank due to a defective check valve. Gas spills on the vehicle and ground, creating an extreme safety hazard. There is a recall (nhtsa campaign id number: 05v034000) for this problem, but chrysler has excluded our vehicle from the recall even though we are having the exact same problem. There are hundreds of examples of other people…
ODI 10382534
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that after refueling and removing the nozzle, fuel started to spill out from the filler neck. The vehicle was taken to an authorized dealer, who diagnosed that the valve was defective and needed to be replaced. The vehicle was repaired, but the failure continued. The manufacturer was made aware of the failure, but offered no assistance and referred the…
ODI 10442523
Fuel System, Gasoline
Tl*the contact owns a 2006 dodge durango. While filling the fuel tank, the contact stated the fuel overflowed and sprayed out. The fuel tank does not indicate when it was full and causes the fuel to spray out. The vehicle was taken to the dealer where the technicians stated the fuel tank needed to be replaced. The contact stated there was a recall on the fuel tank but the vin was not included. The nhtsa campaign id…
ODI 10380933
Fuel System, Gasoline
I have a 2006 dodge durango. Everytime i fuel the vehicle gas spills from the filler neck when it nears the full point. This will happen whether i am running the pump by hand or whether i have the pump in auto fill. I have tried several different gas stations also. If you are not paying attention fuel comes out with enough pressure to cover a person from the knee area down. Not only am i covered in gas but the…
ODI 10380181
Fuel System, Gasoline
During refueling. Once the gas nozzle clicks and the tank is full a great amount of gasoline spews out of the tank. Does not matter what gas station is used. Happens every time and is a definite fire risk. Multiple searches online demonstrate hundreds of results and videos about this exact issue. *tr
ODI 10563826
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. While refueling the vehicle, gasoline began to spill from the fuel filler neck. The failure recurred whenever the contact attempted to refuel the vehicle. The vehicle was taken to an authorized dealer where the contact was advised that the fuel tank assembly would need to be replaced. The vehicle was not repaired. The failure mileage was 55,000 and the current mileage was…
ODI 10395116
Fuel System, Gasoline
When i fill up the gas tank gas will spew out of the filler tube right as the fuel shuts off. This happens more in warmer weather but can happen any time. Will do it most times unless shutting the fuel pump off before the tank is fuel. The gas will shot out, possible up to 1/8 of a gallon. *tr
ODI 10380041
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. When attempting to refuel the vehicle, the contact stated that fuel began to spill back out from the filler neck. The dealer advised the contact that there were no recalls and that he would need to replace the fuel tank. The contact did not inform the manufacturer of the failure nor was the vehicle repaired. The current mileage was 58,138 and the failure mileage was 55,000.
ODI 10397141
Fuel System, Gasoline
Gas no longer automatically shuts off. Gas spills out everytime i refuel. I have to guess when i should stop the fueling but sometimes i miscalculated and it all over my shoes and the ground. Fire hazard in the wait. *tr
ODI 10434438
Fuel System, Gasoline
When filling my 2006 dodge durango with fuel, the automatic shutoff mechanism doesn't work and fuel splashes out or spits out of the gas tank. This has happened approximately 10 times. Now i never fill the tank completely. *tr
ODI 10390155
Filler Pipe And Cap · Fuel System, Gasoline
At the end of refueling the vehicle will have a burst of gasoline that sprays out of the fuel neck and soaks the side of the vehicle as well as the ground and the person refueling if they are standing next to the vehicle. Same as recall campaign for the year prior (05v034000). *tr
ODI 10375343
Fuel System, Gasoline
Fuel sprayed out of the filler tube after filling the tank to full and nozzle clicked off. This has happened on multiple occasions. I no longer fill up all the way to prevent any more overflows and potential fires. Problem is same as 2005 recall but dealer will not repair without a recall for 2006 durango. *tr
ODI 10375291