2006 Dodge Durango Fuel System, Gasoline Problems
- 372
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 372 stored complaint records:
- 0 indicate a crash
- 5 indicate injury
- 0 indicate fire
What owners report
- fuel tank · 38 records
- filler neck · 24 records
- filling tank · 22 records
- every fill · 20 records
- failure mileage · 20 records
- fill tank · 19 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 167 |
| 60–100k mi | 121 |
| 1–30k mi | 35 |
| 100–150k mi | 17 |
| 150–400k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel System, Gasoline
Dodge durango 2006: fuel filler neck problem. When filling the car, fuel can spurt out of the filler neck including spraying on the person filling the tank. Dodge has the identical problem on 2005 cars and issued a recall to replace filler neck and gas tank, but no such recall on other year cars. *tr
ODI 10347144
Fuel System, Gasoline
When filling the gas tank on our 2006 dodge durango, once the tank is full, gas will shoot out of the tank for a couple seconds unless the pump is manually stopped prior to filling the tank. This happens on almost every fill up. *tr
ODI 10345959
Fuel System, Gasoline
When filling up my 06 durango it always overflows when trying to fill the tank. The automatic shutoff on the gas pump will shut off then seconds later gas shoots out the fill tube. This is very unsafe and could cause explosion and hurt many, many people. *tr
ODI 10351612
Fuel System, Gasoline
Beginning about a year and a half ago, my 2006 dodge durango slt began spewing gasoline everytime i filled my car at the gas station. It continues to do this since that time and even though dodge has issued a technical service bulletin for this problem, since my car's vin is not listed as eligible for the extended warranty and repair i am out of luck. I filed an appeal with dodge and it seems the criteria for…
ODI 10452240
Fuel System, Gasoline
I own a 2006 dodge durango that i purchased new. After reaching 60,000 miles, the fuel system began overfilling and spilling out on the ground. At first it was only occasionally but now it does it every time i refuel. When the pump shuts off, a strong burst of gasoline sprays out of the tank. I have read online that many other people have this same problem. There should be a recall on this defective fuel system.
ODI 10377448
Fuel System, Gasoline
The fuel spits out when refueling. The auto shut off does not stop the refueling until the fuel has already begun to spit out of my 2006 dodge durango. *tr
ODI 10342441
Fuel System, Gasoline
References recall nhtsa campaign number 09v003000 for 2005 dodge durango fuel system. My 2006 dodge durango has the same defect as listed in the 2005 recall. A local dodge dealer has inspected and confirmed the defected fuel system gasoline and storage tank assembly in my durango. Dodge will not cover the total cost of this safety repair since there is not a recall on the 2006 and dodge told me to file a complaint…
1 injury
ODI 10375737
Fuel System, Gasoline
2006 dodge durango - every time i fill up the gas tank to full, after it kicks off, gas spews out of the tank and goes all over the place. It sprays all over the side of the car and on to whoever is filling up the tank. This is very unsafe as gas has sprayed on to my face and mouth. I have seen dodge has had this problem with earlier years and has rectified the problem, but they won't acknowledge for 2006 models. I…
ODI 10339429
Fuel System, Gasoline
Purchased a used 2006 dodge durango on june 9, 2010. Mileage was 50633. For the past 3 months during every fill-up, at various gas stations, fuel pump nozzle will click off when tank is full and then a few seconds later gasoline will forcibly flow from the tank spilling about a quart of fuel on the side of vehicle and on the cement. The only thing we have done to correct the failure is to partially fill the gas…
ODI 10354373
Fuel System, Gasoline
I have a 2006 dodge durango that every time i fill up at the gas station, when the tank gets full, the nozzle clicks and a rush of gas spills out. The dodge dealer says it's not covered under a recall covering the same problem on other vehicles. I see there is a recall for 2005 durango's but not 2006's. I have investigated this complaint on the internet and find many 2006 durango owners having the same problem. I am…
ODI 10336704
Fuel System, Gasoline
2006 dodge durango spews gas from filler tube whenever we fill it. Dealer diagnosed problem as a flap valve in gas tank, and said the tank should be replaced (approx. $600). At her suggestion we reported problem to dodge. They talked directly to service manager and authorized the repair, minus a $100 deductible. Vehicle was out of warranty, and we had no extended warranty. Dealer said this was a known problem that…
ODI 10362504
Fuel System, Gasoline
When filling up my 06 durango it always overflows when trying to fill the tank. It happens all the time and at different stations. The tank will fill up and the pump will cut off and then there is a back flow and gas pours out all over the car and the ground. A lot comes out and is dangerous. *tr
ODI 10350329
Fuel System, Gasoline
2006 dodge durango. Consistently, upon finishing filling the fuel tank, up to a quart of fuel will spill out of the fuel filler neck. This poses a potential fire hazard. The issue appears to be similar to the supposedly corrected issue affecting certain 2005 durangos. *tr
ODI 10351717
Fuel System, Gasoline
Tl* the contact owns a 2006 dodge durango. The contact stated that fuel spilled from the fuel tank during refueling. The vehicle was taken to the dealer who confirmed that the fuel tank needed to be replaced. The manufacturer was contacted and advised that the vin was not included in nhtsa campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The vehicle was not repaired.…
ODI 10426719
Fuel System, Gasoline
Gas spills out of gas tank when filling up tank. Known incident and recall issued on other years. *tr
ODI 10332705
Fuel System, Gasoline
After completing refueling, gas will flow out of the nozzle under pressure (about one or two cups) and spill on the car and concrete. This occurs about 1/2 times. *tr
ODI 10331141
Fuel System, Gasoline · Mechanical
I have a 2006 dodge durango and gas overflows and sprays out of the filler neck when tank is filled. Several times i have had fuel sprayed on me when fueling. *tr
ODI 10332329
Fuel System, Gasoline
Tl*the contact owns a 2006 dodge durango. While adding fuel to the vehicle, the fuel pump indicator informed the contact that the fuel tank was full. Fuel began spraying out of the vehicle onto the contact and the ground. The vehicle was not taken to the dealer for diagnostic testing. The vehicle was not repaired. The approximate failure mileage was 33,000.
ODI 10400988
Fuel System, Gasoline
Just purchased a 2006 durango and filled with gas. Gas sprayed all over the vehicle and ground. Online postings shows this to be common but that only 2005 models were recalled, though the exact same problem. As a vehicle owner with a young family this concerns me. As an insurance investigator this disturbs me. I will be taking to a dealer in the next week or two in sioux falls, sd. Can anyone advise me of what i…
ODI 10330730
Fuel System, Gasoline
While refueling my 2006 dodge durango limited at various gas stations between pensacola florida and san antonio texas, fuel comes spewing out of the refuel nozzle once the pump cuts off and the tank is full this has happened over 60 times since owning the vehicle, and at various gas stations across america. My wife has reuined a pair of shoes and a dress because fuel came spewing out and got all over her, the truck…
ODI 10432270
Filler Pipe And Cap · Fuel System, Gasoline
I purchased a 2006 dodge durango 4x4 limited with a 5.7l v8 on 13 may 2010. On three separate occasions from 13-26 may, the valve assembly failed to close on the gas tank filler pipe while refueling resulting in fuel overflow and spillage. This is the same problem that has been identified in the 2005 model year for durangos in nhtsa campaign id number: 05v034000. After checking this website and dodge's, no recalls…
ODI 10332429
Fuel System, Gasoline
While filling my 2006 dodge durango everytime i fill it full the nozzle kicks off and within 1-2 seconds gas come back out of the tank covering the nozzle and anything within 1-3 feet in front of the tank. Dropping about 1/2 gallon of gas everywhere. *tr
ODI 10330978
Fuel System, Gasoline
When pumping gas the pump shuts off and then the gas shoots out all over me and the side of the car. It happens every time i get gas and covers me and the side of the car with the spillage. Nothing has been done to fix the problem. I was told because i bought it used it was not something the company would fix. I hope a fire does not occur because of this overflow problem. *tr
ODI 10329328
Fuel System, Gasoline
My 2006 dodge durango began having issues with the fuel tank one year ago. Every time i fill up the tank, after the nozzle automatically shuts off, gas spews back out of the car onto me and the exterior of the vehicle. May 2011 a service shop found that a solenoid had failed and replaced it. They also found that the surge canister was holding gasoline, as it likely is filled when the tank spews gas back out.…
ODI 10404107
Fuel System, Gasoline
2006 dodge durango - when filling it up with gasoline, just after the pump clicks off a large amount of gas will come spraying out from the filler entrance. This has happened at different gas stations. *tr
ODI 10331490