2005 Dodge Durango Fuel/Propulsion System Problems
- 186
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 186 stored complaint records:
- 1 indicate a crash
- 3 indicate injury
- 1 indicate fire
What owners report
- fuel tank · 43 records
- filler neck · 24 records
- fuel system · 20 records
- failure mileage · 20 records
- check valve · 17 records
- fuel filler · 15 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 55 |
| 100–150k mi | 53 |
| 150–400k mi | 23 |
| 30–60k mi | 20 |
| 1–30k mi | 9 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. While attempting to fuel the vehicle, the contact was unable to insert the entire fuel pump nozzle into the fuel filler neck. The fuel filler neck would only allow a certain amount of fuel to enter at a time. The vehicle was taken to the dealer where it was diagnosed that the fuel filler neck and fuel tank parts needed to be replaced. The vehicle was repaired, but the…
ODI 10978810
Fuel/Propulsion System
Fuel tank overflows every time when fueling. I try to pump as slowly as possible but fuel still runs down side of truck when about 3/4 full every single fill-up. Last happened previous saturday. This has been occurring last 15,000 miles. Local dealer claims nothing is wrong.
ODI 10957398
Engine · Fuel/Propulsion System
Engine cuts off at any speed, but especially at low idle, when nearing an intersection, or turning the vehicle at a lower, safer speed. This happens on highway, residential streets, stoplights, basically anywhere at anytime.
ODI 10954463
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that there was a recall regarding the fuel tank filler inlet check valve. The contact's vehicle was not included. The contact stated that fuel leaked out of the fuel tank after filling the tank. The contact noticed a strong odor of fuel while driving. The contact took the vehicle to a dealer. The manufacturer was notified of the issue. The failure mileage…
ODI 10956138
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. While attempting to refuel the vehicle, fuel would erroneously escape from the filler neck and spill out of the vehicle. The cause of the failure was not determined. Griffin chrysler dodge (505 7th st, west tifton, ga) stated that the vehicle was not included in nhtsa campaign number: 09v003000 (fuel system), although the failures were the same. The manufacturer was not…
ODI 11187043
Fuel/Propulsion System
Reason for filing a vehicle safety complaint is as follows; every time i have tried to fill-up my gas tank on my 2005 dodge durango, the gas not only starts to shoot out of the tank itself, but also all over my truck, myself and all over the floor. This happens each time i fill my suv regardless of the gas station i go to.
ODI 10927909
Fuel/Propulsion System
Everytime i fill the tank up it spits fuel back out at me.
ODI 10935929
Fuel/Propulsion System
Fuel tank overflows when being filled- doesn't auto stop the pump like it should. This happens whenever the car's gas tank is filled unless the amount of gas needed is estimated lower and the pump is stopped manually.
ODI 10926727
Engine · Fuel/Propulsion System · Unknown Or Other
I have a 2005 dodge durango with the 5.7 hemi engine.. It has 80,000 miles and just recently the engine started shutting off at random times when driving, mostly when i hit a bump in the road.. I have researched this with the national highway safety board website and see there is a hundreds of complaints from feburary 2005 thru present .. There was an investigation opened in 2005 pe05-027 then it was transferred to…
ODI 10906748
Fuel/Propulsion System
When fueling vehicle the fuel will unpredictable overflow and cause gasoline to pour on vehicle and unto the ground. Enough fuels overflows to cause puddles of gasoline to form on the ground. If you are standing close to intake it will spray fuel on person operating the pumb. The problem is causing rusting on vehicle.
ODI 10901940
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. While attempting to refuel the vehicle, there was evidence of a fuel leakage coming from the filler neck of the fuel tank. The contact stated that the failure recurred on every fuel fill up. The vehicle was not diagnosed or repaired. The vehicle was not included in nhtsa campaign number: 09v003000 (fuel system, gasoline). The manufacturer was notified of the failure. The…
ODI 10948609
Fuel/Propulsion System
My dodge durango is filled with gas it will overflow. The gas pump kicks off and then gas comes spraying back out and spills gas down the side of the car. It will continue pushing gas out for about 30 seconds to a minute. I'm afraid to fill the tank to capacity due to the fire danger or explosion.
ODI 11022915
Fuel/Propulsion System
Gas comes spewing out of the tank when i'm filling up at the gas station. This only happens with i'm trying to "fill" the tank, at the end of the filling when the pump should stop due to the tank being full. It does not spew out if i'm just putting "some" gas in the tank. This happens at all gas stations so it seems as though this is an issue with the vehicle and not the pump. I've had this problem for several years…
ODI 10885458
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that when attempting to refuel the vehicle, fuel leaked from the gasket once the fuel level reached half a tank. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 24,000.
ODI 10937636
Body · Fuel/Propulsion System
My 05 dodge durango, which i am the only owner of, overflows gas while filling up the tank. I was told it is a recall, i called the local dealership to schedule an appointment to fix it, i was treated with absolute disrespect and was told my car was already fixed through the warranty, i assured them i was the only owner and it was never fixed, they again told me it was and they would not pay for it to get fixed…
ODI 11000129
Fuel/Propulsion System
When putting gas in the vehicle it does not stop once full it will splash gas on the vehicle, person putting the gas in and will continue to spill onto the pavement. This happens every time you put gas in the vehicle.
ODI 10852603
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. While refueling the vehicle, fuel spewed out of the filler neck onto the ground even though the fuel tank level was not to the full capacity. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 115,000.
ODI 10861718
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that when filling the tank with fuel, the fuel pump would not automatically stop as intended. As a result, fuel overflowed and leaked from the vehicle. The vehicle was taken to the dealer where it was diagnosed that the shut off valve was faulty and needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 99,000.
ODI 10860901
Fuel/Propulsion System
Gas spilling and squirting out when refueling. This happens each and every time i refuel. I just bought this 2005 dodge durango 2 months ago. Gas spills and squirts on my clothes and feet. This is dangerous! Please help me get this resolved before i catch on fire or set fire to someone else nearby. I just bought this vehicle at jrs auto sales in tacoma, wa i bought this 2005 dodge durango on january 9, 2016 and gas…
1 injury
ODI 10840384
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. While the contact was filling the fuel tank, fuel spilled out. The contact was not able to complete filling the tank. There were no warning indicators illuminated. Bender chrysler dodge jeep ([redacted], clovis, nm 88101, [redacted]) replaced the fuel check valve. The manufacturer was notified and did not assist. The failure mileage was 190,000.
ODI 11172156
Fuel/Propulsion System
FUEL KEEPS SPITTING BACK UP THE SPOUT..
ODI 10853177
Electrical System · Exterior Lighting · Fuel/Propulsion System
When filling the gas tank, a large amount of fuel always shoots out of the filler neck and spills onto vehicle, ground, and objects around vehicle. Also the vehicle does not come with tpms, however the tpms warning light on the instrument panel stays on all the time. Also if the rear lift gate is opened the cargo light indicator on the instrument panel stays on until you open and close the lift gate a total of two…
ODI 10794306
Fuel/Propulsion System
Tl* the contact owns a 2005 dodge durango. The contact stated that the fuel tank filler tube inlet check valve was not closed as intended. As a result, fuel spilled out while refueling the vehicle. The failure occurred constantly. The vehicle was serviced under nhtsa campaign number: 09v003000 (fuel system, gasoline), but the remedy failed to repair the vehicle. The manufacturer was notified of the failure. The…
ODI 10825887
Fuel/Propulsion System
When filling car with gas it shoots out filler tube spilling gas on the side of the car and ground.
ODI 10789268
Fuel/Propulsion System
Vehicle spits gas from fuel tank inlet & smells of fuel outside of the vehicle.
ODI 10809584